Go Back   EcoModder Forum > Off-Topic > The Lounge
Register Now
 Register Now
 


Reply  Post New Thread
 
Submit Tools LinkBack Thread Tools
Old 02-05-2018, 11:02 AM   #1 (permalink)
Not Doug
 
Xist's Avatar
 
Join Date: Jun 2012
Location: Show Low, AZ
Posts: 12,186

Chorizo - '00 Honda Civic HX, baby! :D
90 day: 35.35 mpg (US)

Mid-Life Crisis Fighter - '99 Honda Accord LX
90 day: 34.2 mpg (US)

Gramps - '04 Toyota Camry LE
90 day: 35.39 mpg (US)

Don't hit me bro - '05 Toyota Camry LE
90 day: 35.79 mpg (US)
Thanks: 7,217
Thanked 2,217 Times in 1,708 Posts
Sandy Munro compares Model S built quality to a 90s Kia

I think we have discussed Munro before, he tears down everything from small appliances to airplanes to tell competitors how stuff works. https://jalopnik.com/tesla-model-3-t...ual-1822678045

People in the comments said to cut them slack, they have been building cars for as long as Kia had in the 90s. If I am getting a mortgage for a car, I want perfection! I remember sharing an article about how difficult it was to open the trunk on a Prius when the battery died. Someone said they fixed that in later models. A comment on the Jalopnik page:

Quote:
I do remember being in a parking lot that had an EV charging station, and some dude with a Leaf came up and asked me to give him a jump because his battery had died, so he couldn’t get the battery charger door open to plug the car in. That struck me as an appallingly stupid design.
There were complaints like those about the Tesla. Don't run out of gas, military-grade jet fuel, or electricity, but if you do, there should be a better alternative than selling your car for parts.

  Reply With Quote
Alt Today
Popular topics

Other popular topics in this forum...

   
Old 02-05-2018, 02:23 PM   #2 (permalink)
Master EcoModder
 
Join Date: Jun 2008
Location: Earth
Posts: 5,209
Thanks: 225
Thanked 811 Times in 594 Posts
I'd call those design flaws (AKA bugs), rather than build quality issues. Same as my 1st-gen Insight, which doesn't run if the 12-volt battery is (nearly) dead, even though the traction battery is fully charged.
  Reply With Quote
Old 02-05-2018, 02:31 PM   #3 (permalink)
Master EcoWalker
 
RedDevil's Avatar
 
Join Date: Dec 2012
Location: Nieuwegein, the Netherlands
Posts: 3,998

Red Devil - '11 Honda Insight Elegance
Team Honda
90 day: 47.72 mpg (US)
Thanks: 1,711
Thanked 2,245 Times in 1,454 Posts
The traction battery needs a controller to be useful and that controller is powered by the 12V system.
I don't mind jumping an EV to get it working again. The charge port is useless if there is no 12V as the battery brain is needed to be able to charge anyway.

The fools that dragged a BMW I3, wheels locked and all, onto a tow truck and toward a BWM dealership only to have the dealer jump it and drive it off by its own force should have RTFM tattooed somewhere though.
__________________
2011 Honda Insight + HID, LEDs, tiny PV panel, extra brake pad return springs, neutral wheel alignment, 44/42 PSI (air), PHEV light (inop), tightened wheel nut.
lifetime FE over 0.2 Gmeter or 0.13 Mmile.


For confirmation go to people just like you.
For education go to people unlike yourself.
  Reply With Quote
Old 02-05-2018, 03:18 PM   #4 (permalink)
Administrator
 
Daox's Avatar
 
Join Date: Dec 2007
Location: Germantown, WI
Posts: 11,203

CM400E - '81 Honda CM400E
90 day: 51.49 mpg (US)

Daox's Grey Prius - '04 Toyota Prius
Team Toyota
90 day: 49.53 mpg (US)

Daox's Insight - '00 Honda Insight
90 day: 64.33 mpg (US)

Swarthy - '14 Mitsubishi Mirage DE
Mitsubishi
90 day: 56.69 mpg (US)

Daox's Volt - '13 Chevrolet Volt
Thanks: 2,501
Thanked 2,585 Times in 1,553 Posts
Last I checked, no normal cars start with a dead 12V battery... Is this a design flaw too?
__________________
Current project: A better alternator delete
  Reply With Quote
Old 02-05-2018, 03:50 PM   #5 (permalink)
Not Doug
 
Xist's Avatar
 
Join Date: Jun 2012
Location: Show Low, AZ
Posts: 12,186

Chorizo - '00 Honda Civic HX, baby! :D
90 day: 35.35 mpg (US)

Mid-Life Crisis Fighter - '99 Honda Accord LX
90 day: 34.2 mpg (US)

Gramps - '04 Toyota Camry LE
90 day: 35.39 mpg (US)

Don't hit me bro - '05 Toyota Camry LE
90 day: 35.79 mpg (US)
Thanks: 7,217
Thanked 2,217 Times in 1,708 Posts
That is what you deserve for purchasing a car with an automatic.
  Reply With Quote
Old 02-05-2018, 09:47 PM   #6 (permalink)
It's all about Diesel
 
cRiPpLe_rOoStEr's Avatar
 
Join Date: Oct 2012
Location: Porto Alegre, Rio Grande do Sul, Brazil
Posts: 12,548
Thanks: 0
Thanked 1,622 Times in 1,447 Posts
Quote:
Originally Posted by Xist View Post
People in the comments said to cut them slack, they have been building cars for as long as Kia had in the 90s. If I am getting a mortgage for a car, I want perfection!
It's like comparing apples with oranges. Kia was still doing nothing more than copying Mazda designs, plus it targeted to a cheaper end on the global markets, while Tesla has always been after a more affluent one.


Quote:
Originally Posted by Daox View Post
Last I checked, no normal cars start with a dead 12V battery...
At least the ones with a manual transmission can be push-started
  Reply With Quote
Old 02-06-2018, 02:33 PM   #7 (permalink)
Master EcoModder
 
Join Date: Jun 2008
Location: Earth
Posts: 5,209
Thanks: 225
Thanked 811 Times in 594 Posts
Quote:
Originally Posted by Daox View Post
Last I checked, no normal cars start with a dead 12V battery... Is this a design flaw too?
Strange, because I've started a number of normal cars with an (almost - not enough juice to turn the starter) dead battery. You just give it a good push (or hope you're pointed downhill), hop in, pop the clutch, and go.

Indeed, I probably started my old Austin-Healey that way almost as often as I used the started. Lucas electrics, you know?

And yes, it is a design flaw because it would be simple to make the DC/DC converter provide current from the traction pack.
  Reply With Quote
Old 02-06-2018, 02:48 PM   #8 (permalink)
Human Environmentalist
 
redpoint5's Avatar
 
Join Date: Aug 2010
Location: Oregon
Posts: 12,396

Acura TSX - '06 Acura TSX
90 day: 24.19 mpg (US)

Lafawnda - '01 Honda CBR600 F4i
90 day: 47.32 mpg (US)

Big Yeller - '98 Dodge Ram 2500 base
90 day: 21.82 mpg (US)

Prius Plug-in - '12 Toyota Prius Plug-in
90 day: 57.64 mpg (US)

Mazda CX-5 - '17 Mazda CX-5 Touring
90 day: 26.68 mpg (US)

Chevy ZR-2 - '03 Chevrolet S10 ZR2
90 day: 17.14 mpg (US)
Thanks: 4,192
Thanked 4,380 Times in 3,354 Posts
Quote:
Originally Posted by jamesqf View Post
And yes, it is a design flaw because it would be simple to make the DC/DC converter provide current from the traction pack.
It's not quite that simple because the traction battery must be disconnected when not used for safety. This means the 12v battery is necessary to actuate the contactor that connects the traction battery to the rest of the vehicle circuitry.

My thought was a momentary switch that can be manually operated that closes the contactors. Hold the switch long enough to charge the 12v battery, a minute or 2, and then the 12v battery can take over holding the contactor closed.

The power required to "start" an EV is very low compared to an ICE. A very small 12v source is all that is needed to provide just enough to run the computer and close the contactor, then the traction battery takes over.
__________________
Gas and Electric Vehicle Cost of Ownership Calculator







Give me absolute safety, or give me death!
  Reply With Quote
The Following 2 Users Say Thank You to redpoint5 For This Useful Post:
niky (02-12-2018), roosterk0031 (02-06-2018)
Old 02-06-2018, 03:41 PM   #9 (permalink)
...beats walking...
 
Join Date: Jul 2009
Location: .
Posts: 6,190
Thanks: 179
Thanked 1,525 Times in 1,126 Posts
Small, super-powerful, 12Vdc Li-ion battery inside a simple, old-fashioned, IGNITION KEY; just plug it IN to "start" the 12Vdc electronics.
  Reply With Quote
The Following 3 Users Say Thank You to gone-ot For This Useful Post:
freebeard (02-06-2018), niky (02-12-2018), redpoint5 (02-06-2018)
Old 02-06-2018, 04:15 PM   #10 (permalink)
Master EcoWalker
 
RedDevil's Avatar
 
Join Date: Dec 2012
Location: Nieuwegein, the Netherlands
Posts: 3,998

Red Devil - '11 Honda Insight Elegance
Team Honda
90 day: 47.72 mpg (US)
Thanks: 1,711
Thanked 2,245 Times in 1,454 Posts
Quote:
Originally Posted by Old Tele man View Post
Small, super-powerful, 12Vdc Li-ion battery inside a simple, old-fashioned, IGNITION KEY; just plug it IN to "start" the 12Vdc electronics.
A 19th century telephone with swing-to-ring generator

__________________
2011 Honda Insight + HID, LEDs, tiny PV panel, extra brake pad return springs, neutral wheel alignment, 44/42 PSI (air), PHEV light (inop), tightened wheel nut.
lifetime FE over 0.2 Gmeter or 0.13 Mmile.


For confirmation go to people just like you.
For education go to people unlike yourself.
  Reply With Quote
Reply  Post New Thread


Thread Tools




Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Content Relevant URLs by vBSEO 3.5.2
All content copyright EcoModder.com