Go Back   EcoModder Forum > EcoModding > Off-Topic Tech
Register Now
 Register Now
 

Reply  Post New Thread
 
Submit Tools LinkBack Thread Tools
Old 10-03-2011, 04:46 PM   #1 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
When is "old gas" too old to use?

An article on Autospeed got me wondering about this.

I was surprised to read the experts giving answers that were much shorter than I would have expected.

Depending on whom you ask, gasoline is good for ...
  • 6 months - in a sealed container, after which it starts to degrade
  • up to 12 months in a sealed container
  • "several months" old fuel in your tank risks fuel system problems
  • "several weeks" is enough to detect octane degradation, based on dyno testing
Read more from: The Life of Fuel - How long does fuel last in your car's tank?

When I got the Firefly, it had been sitting, the tank nearly full, for seven years. The engine started normally on the old gasoline, and it ran apparently fine when I test-drove it around the block.


7 year old gas

7 years seemed pretty extreme, though, and I was warned that old gas could gum up the intake valves and make them stick. So I drained the fuel tank to nearly empty, drove straight to a gas station and filled up with fresh gas before driving it home.

OK, so if 7 years is too much, how about four years? That's how old the gas is in this 1990 Swift GTi:


4 year old gas

... and with a boost, it started right up after sitting in a field for that long.

On the other hand, I have had trouble running a 2-stroke boat motor with fuel that was 2 years old. Maybe it depends on the engine, or the oil mix causes things to go wonky sooner.

Autospeed: The Life of Fuel - How long does fuel last in your car's tank?

__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Alt Today
Popular topics

Other popular topics in this forum...

   
Old 10-03-2011, 04:48 PM   #2 (permalink)
Administrator
 
Daox's Avatar
 
Join Date: Dec 2007
Location: Germantown, WI
Posts: 11,203

CM400E - '81 Honda CM400E
90 day: 51.49 mpg (US)

Daox's Grey Prius - '04 Toyota Prius
Team Toyota
90 day: 49.53 mpg (US)

Daox's Insight - '00 Honda Insight
90 day: 64.33 mpg (US)

Swarthy - '14 Mitsubishi Mirage DE
Mitsubishi
90 day: 56.69 mpg (US)

Daox's Volt - '13 Chevrolet Volt
Thanks: 2,501
Thanked 2,585 Times in 1,553 Posts
I have a 1993 Toyota Tercel sitting in the driveway. I know the gas is at least 4 years old. I fire it up a few times a year to keep things oiled. Never has any issues...
__________________
Current project: A better alternator delete
  Reply With Quote
Old 10-03-2011, 05:09 PM   #3 (permalink)
...beats walking...
 
Join Date: Jul 2009
Location: .
Posts: 6,190
Thanks: 179
Thanked 1,525 Times in 1,126 Posts
...my lawn-mower sits all winter, and seems to start OK each spring.
  Reply With Quote
Old 10-03-2011, 05:44 PM   #4 (permalink)
Master EcoModder
 
Ryland's Avatar
 
Join Date: Jan 2008
Location: Western Wisconsin
Posts: 3,903

honda cb125 - '74 Honda CB 125 S1
90 day: 79.71 mpg (US)

green wedge - '81 Commuter Vehicles Inc. Commuti-Car

Blue VX - '93 Honda Civic VX
Thanks: 867
Thanked 433 Times in 353 Posts
Most modern cars have sealed gas tanks so very little fuel vapor leaks out, they also have fuel injection so there is little to no air in the rest of the fuel system.
Motorcycles that have gasoline that is 9 months old or more tend to have issues because there are so many vents in the carburetors and the gas cap is more or less an open vent, because of this the volatile part of the gasoline evaporates and escapes leaving behind varnish, this is often made worse with ethanol in the gasoline because the alcohol sucks up water out of the air the ethanol then easily evaporates leading to water in the gas.

So I figure if gasoline is in a can or tank that is vented it has a shelf life of 6 months before issues start to show up, if it's sealed in a safety can, or the gas tank of a vehicle with fuel injection it's good for a year or more.

The motorcycle shop that I used to work part time at has a lot of motorcycles come in every spring with bad gasoline and I still get calls from friends who have lawn mowers that have year old gas from a gas can put in them and don't want to run, change the gas and they run, put that old gas in a fuel injected car and it will run as well.
  Reply With Quote
Old 10-03-2011, 05:45 PM   #5 (permalink)
Banned
 
Join Date: Dec 2009
Location: NY
Posts: 865
Thanks: 29
Thanked 111 Times in 83 Posts
Quote:
Originally Posted by Old Tele man View Post
...my lawn-mower sits all winter, and seems to start OK each spring.
I store quite a bit of gasoline in proper 5 gallon storage containers. I've had some of it for up to 2-3 years, still usable, with no bad effects. The worst part is that some of the volume will be lost to evaporation, no matter how you store it.

Gasoline contains additives. If you are going to leave gas in a snow blower or lawnmower, either drain the tank completely (preferably) or keep it entirely full. Gasoline contains additives. If you've ever had to rebuild a lawnmower carb you might find it full of goo from someone who left it sitting for several years with gas still in it. The gas evaporates and leaves a lot of residue that clogs the carb.
  Reply With Quote
Old 10-03-2011, 06:43 PM   #6 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
That must be why several old-timers that I know with outboard boat motors will disconnect or shut off the fuel line to the engine -- while it is running -- several minutes before they plan to stop it. Then let it run out and stall when they've docked, with the carb dry. They do this if it's going to be sitting even for a week or more.
__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Old 10-03-2011, 06:45 PM   #7 (permalink)
.........................
 
darcane's Avatar
 
Join Date: Aug 2009
Location: Buckley, WA
Posts: 1,597
Thanks: 391
Thanked 488 Times in 316 Posts
My 1968 Chevy pickup had gas in it that was about four years old. It ran just fine, but the filter clogged pretty quickly. No sealed tank here.

I've since drained the rest of the gas out until I can more regularly drive it.
__________________
Past Cars:

2001 Civic HX Mods

CTS-V

2003 Silverado Mods
  Reply With Quote
Old 10-03-2011, 08:00 PM   #8 (permalink)
Wannabe greenie
 
Join Date: Aug 2008
Location: Yorba Linda, CA
Posts: 1,098

The Clunker (retired) - '90 Honda Accord EX sedan
Team Honda
90 day: 29.49 mpg (US)

Mountain Goat - '96 Ford Ranger XLT 4x4 SuperCab
90 day: 18 mpg (US)

Zippy - '10 Kymco Agility 125
90 day: 65.03 mpg (US)
Thanks: 5
Thanked 53 Times in 40 Posts
Quote:
Originally Posted by MetroMPG View Post
That must be why several old-timers that I know with outboard boat motors will disconnect or shut off the fuel line to the engine -- while it is running -- several minutes before they plan to stop it. Then let it run out and stall when they've docked, with the carb dry. They do this if it's going to be sitting even for a week or more.
I've known of several cars that ran fine with 4+ year old gas in the tank. On the other hand, we run our outboards dry as well. (It's amazing how long a Honda 5 hp 4-stroke will run after you disconnect the fuel line.)
__________________

  Reply With Quote
Old 10-03-2011, 10:05 PM   #9 (permalink)
Master EcoModder
 
Ryland's Avatar
 
Join Date: Jan 2008
Location: Western Wisconsin
Posts: 3,903

honda cb125 - '74 Honda CB 125 S1
90 day: 79.71 mpg (US)

green wedge - '81 Commuter Vehicles Inc. Commuti-Car

Blue VX - '93 Honda Civic VX
Thanks: 867
Thanked 433 Times in 353 Posts
The issues with old gas include varnish and varnish flakes that clog up jets in smaller engine carburetors, so a 1.5L carburetor is going to clog up more easily then a 6 litter engine on a truck would, so a string trimmer is going to be fussy while a tractor might not be, and on something like a 2 stroke out board engine that is sensitive and will burn a piston if you run it lean it's best not to risk a partial clogged carburetor, where an old single cylinder John Deere tractor doesn't even care if there is water in the gasoline.
  Reply With Quote
Old 10-03-2011, 10:44 PM   #10 (permalink)
Banned
 
Join Date: Dec 2009
Location: NY
Posts: 865
Thanks: 29
Thanked 111 Times in 83 Posts
Quote:
Originally Posted by MetroMPG View Post
That must be why several old-timers that I know with outboard boat motors will disconnect or shut off the fuel line to the engine -- while it is running -- several minutes before they plan to stop it. Then let it run out and stall when they've docked, with the carb dry. They do this if it's going to be sitting even for a week or more.
Exactly. I'm "on the wrong side of fifty" and I always do this with my snowblowers. They are 50 and 40 years old, respectively. (I bought both of them used and have had each of them for "only" about 25 years.) One had a gas tank that was full of rust and crud when I got it, and I had to put a replacement tank on it.

Some winters are mild and you might only need to use the blower a few times. No matter. I installed a shut off valve in the fuel line and let it run until stalling out whenever I use it. Then I empty the gas tank fully at the end of the season. With the lawnmower I only empty the tank out when putting it away for the winter. You'll never go wrong in doing that.

  Reply With Quote
The Following User Says Thank You to Thymeclock For This Useful Post:
Ryland (10-03-2011)
Reply  Post New Thread


Thread Tools




Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Content Relevant URLs by vBSEO 3.5.2
All content copyright EcoModder.com