Go Back   EcoModder Forum > EcoModding > Aerodynamics
Register Now
 Register Now
 

Reply  Post New Thread
 
Submit Tools LinkBack Thread Tools
Old 12-15-2007, 02:49 AM   #1 (permalink)
Giant Moving Eco-Wall
 
DifferentPointofView's Avatar
 
Join Date: Dec 2007
Location: The Dale, IL (or A-Dale)
Posts: 1,120

The Jeep! - '95 Jeep Grand Cherokee ZJ Laredo
90 day: 23.75 mpg (US)

The Caliber - '07 Dodge Caliber R/T
90 day: 30.6 mpg (US)

The 'Scort - '98 Ford Escort LX
Thanks: 0
Thanked 7 Times in 6 Posts
Easy Aero Fix? (Modding a pickup?)

Would it be possible to take a small truck and turn it into a mpg champ by a few homemade remedy's and an engine swap? The boat tailing part would be really easy since the truck is already divided in half. Some clear plastic and tape would easily make Cd improve dramatically, if you took plastic from the roof to the tailgate, and be much better than a full camper cover over the bed because it has a kammback effect right? you could easily lower it and do easy aeromods but... has this been successful?

__________________


Yea.. I drive a Jeep and I'm on a fuel economy site, but you just wouldn't understand... "It's a Jeep thing!" *Jeep Wave*

Did I Use Too Many Abbreviations? Here's The Abbreviations List
  Reply With Quote
Alt Today
Popular topics

Other popular topics in this forum...

   
Old 12-15-2007, 05:38 AM   #2 (permalink)
EcoModding Apprentice
 
Join Date: Dec 2007
Location: Melbourne
Posts: 152

The Mighty Mira - '92 Daihatsu Mira
90 day: 61.32 mpg (US)
Thanks: 0
Thanked 7 Times in 7 Posts
Yes, I've been thinking this for a long time. On a lot of trucks, you'd get enough angle to make it meet at the top of the tailgate. On others, you might not.
__________________
"Every body perseveres in its state of being at rest or of moving uniformly straight forward, except insofar as it is compelled to change its state by force impressed." - Isaac Newton
  Reply With Quote
Old 12-15-2007, 10:40 AM   #3 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
Quote:
Originally Posted by DifferentPointofView View Post
has this been successful?


http://www.evworld.com/view.cfm?sect...le&storyid=870
__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Old 12-15-2007, 10:43 AM   #4 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
Newton: you've got a class of vehicle in Australia not sold in North America that's ideally suited to this approach: the car-based "ute". (Correct me if I'm wrong.)



Far better than modding a truck, since they're going to be lighter, lower, and will likely have better aerodynamics from the get go, even before the mods.
__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Old 12-15-2007, 11:25 PM   #5 (permalink)
Giant Moving Eco-Wall
 
DifferentPointofView's Avatar
 
Join Date: Dec 2007
Location: The Dale, IL (or A-Dale)
Posts: 1,120

The Jeep! - '95 Jeep Grand Cherokee ZJ Laredo
90 day: 23.75 mpg (US)

The Caliber - '07 Dodge Caliber R/T
90 day: 30.6 mpg (US)

The 'Scort - '98 Ford Escort LX
Thanks: 0
Thanked 7 Times in 6 Posts
I wonder why people don't do that more often, especially for the ones who actually need the truck part, they could craft a removable kammback so when they need to load up they can do so easily. And for added ground clearance, you could get airbags *w/ on board air compressor* to raise the vehicle when needed, and lower it for daily use with the flip of a switch.
__________________


Yea.. I drive a Jeep and I'm on a fuel economy site, but you just wouldn't understand... "It's a Jeep thing!" *Jeep Wave*

Did I Use Too Many Abbreviations? Here's The Abbreviations List
  Reply With Quote
Old 01-06-2008, 03:31 PM   #6 (permalink)
EcoModding Lurker
 
Join Date: Jan 2008
Posts: 10
Thanks: 0
Thanked 0 Times in 0 Posts
That fast back crap won't help a bit, it will only add weight. A pickup truck already gets that effect by the turbulant air behind the cab with no extra weight.

If you want to better the aero in the bed area: use a tonneau cover and put a 6-8" piece of aluminum extending the roof off the back of the cab and tonneau cover over the tailgate. that should get you up to 2mpg at highway speeds with minimal weight. A truck cap with the extension off the back would also do.

Plug any holes in front, lower truck, add a front air dam, remove trailer hitch and replace rr bumper with roll pan, remove all extra weight. Get smaller mirrors. Use under-drive engine pulleys. tune up the truck. Increase gearing
  Reply With Quote
Old 01-06-2008, 03:32 PM   #7 (permalink)
Dartmouth 2010
 
SVOboy's Avatar
 
Join Date: Nov 2007
Location: Hanover, NH
Posts: 6,447

Vegan Powa! - '91 Honda CRX DX
Team Honda
90 day: 66.52 mpg (US)
Thanks: 92
Thanked 122 Times in 90 Posts
Send a message via AIM to SVOboy Send a message via MSN to SVOboy Send a message via Yahoo to SVOboy
Quote:
Originally Posted by Smoky View Post
That fast back crap won't help a bit, it will only add weight. A pickup truck already gets that effect by the turbulant air behind the cab with no extra weight.

If you want to better the aero in the bed area: use a tonneau cover and put a 6-8" piece of aluminum extending the roof off the back of the cab and tonneau cover over the tailgate. that should get you up to 2mpg at highway speeds with minimal weight. A truck cap with the extension off the back would also do.

Plug any holes in front, lower truck, add a front air dam, remove trailer hitch and replace rr bumper with roll pan, remove all extra weight. Get smaller mirrors. Use under-drive engine pulleys. tune up the truck. Increase gearing
But aerodynamics > weight, so I challenge that assertion.
  Reply With Quote
Old 01-06-2008, 03:45 PM   #8 (permalink)
EcoModding Lurker
 
Join Date: Jan 2008
Posts: 10
Thanks: 0
Thanked 0 Times in 0 Posts
Quote:
Originally Posted by SVOboy View Post
But aerodynamics > weight, so I challenge that assertion.
In a wind tunnel, you are correct. I thought everyone was looking for real-world application. I don't mean to be a smartass, sorry.

I have worked with many efficiency consultants, aero scientists and powertrain engineers in my field of study. I believe I have a good understanding of the basics. I will admit I am not an expert! I do however like helping out anyone that would like input with the limited knowledge I have. Share the wealth and we are all better for it!

*I don't know if this will post correctly, I am a forum newbie so please cut me some slack!
  Reply With Quote
Old 01-06-2008, 04:53 PM   #9 (permalink)
EcoModding Lurker
 
Join Date: Jan 2008
Posts: 10
Thanks: 0
Thanked 0 Times in 0 Posts
Quote:
Originally Posted by SVOboy View Post
But aerodynamics > weight, so I challenge that assertion.
Sorry to keep beating this to death.

Apples to apples:

Honda Insight:
1,9xx pounds
.25 coefficient of drag
70 mpg EPA (old math)

Toyota Prius:
2,9xx pounds
.26 coefficient of drag
60 mpg EPA (old math)

What's the difference? weight.

Replace all that hybrid crap and motor with a VW 1.9 turbo diesel running bio and it would be hovering closer to the magic 100mpg than either of these.
  Reply With Quote
Old 01-06-2008, 04:58 PM   #10 (permalink)
Dartmouth 2010
 
SVOboy's Avatar
 
Join Date: Nov 2007
Location: Hanover, NH
Posts: 6,447

Vegan Powa! - '91 Honda CRX DX
Team Honda
90 day: 66.52 mpg (US)
Thanks: 92
Thanked 122 Times in 90 Posts
Send a message via AIM to SVOboy Send a message via MSN to SVOboy Send a message via Yahoo to SVOboy
There are lots of other differences besides weight.

If you compare the 2006 models, both with CVT, using new EPA ratings you get this:

Insight ------- Prius
47 MPG --- 46 MPG

  Reply With Quote
Reply  Post New Thread


Thread Tools




Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Content Relevant URLs by vBSEO 3.5.2
All content copyright EcoModder.com