Go Back   EcoModder Forum > EcoModding > Aerodynamics
Register Now
 Register Now
 

Reply  Post New Thread
 
Submit Tools LinkBack Thread Tools
Old 11-19-2008, 09:10 PM   This thread is in the EcoModder Project Library | #1 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
Minivan Kardboard Kammback boosts MPG +3.7% (6.6%, counting roof rack delete)

While Trebuchet03 shows us how to do things by the book with CFD (computational fluid dynamics) to optimize a Kammback shape on his Jetta sedan, I employed the other kind of CFD on my brother's minivan:

Cardboard Fabrication with Ducttape

This is a variation of Craig Vetter's CAD process: Cardboard Aided Design

This was an A-B-A on road test under perhaps the most ideal conditions I've ever encountered on my favourite test road. No wind, no traffic, perfectly functioning cruise control , tight distribution in the results. I'll post the full details later, but here's the skinny:

Vehicle is a 2005 Pontiac Montana, long wheelbase version, 3.4L V6, automatic...





(More photos below in post #20)

This roughly slapped together Kammback, with fairly conservative angles (10 degree plan & roof taper), improved fuel economy by 3.7% in AAAA BB AA results.

If you add in the initial roof rack removal I did to get to the clean roof, the total fuel economy improvement was +6.6%. That's significant, and hopefully may motivate some of you van/trucklet drivers.

Absolutely nothing new here of course. Much attention has gone to studying and reducing the size of the wake behind trucks, since their cargo-carrying capability dictates a boxy profile with no taper at all. Researchers have known for decades that:


Aerodynamic drag can be significantly reduced with trailer add-ons that reduce the wake and increase the base pressure. - Source: SAE 2000-01-2209

Edit: added the following, Nov 23...

Details of the test...

-
Test speed: 88.5 km/h / 55 mph
- Cruise control set once, cancelled with the brake pedal between runs; "resumed" for subsequent runs

- Bidirectional averaged runs on a straight and nearly level test route; runs were abandoned & re-run where I was overtaken or caught up to another vehicle (aero interference)

- Wind conditions were perfect: none!




A runs, average of all: 33.72 mpg (US)
A runs, standard deviation (of average of bi-dir pairs): 0.35 mpg

B runs, average: 34.975 mpg (US)
B runs, standard deviation (of average of bi-dir pairs): 0.18 mpg

Improvement of B over A: 1.255 mpg / 3.7%

Roof racks on, Kammback off (one bi-dir run): 32.8 mpg (US)
Improvement of B over roof racks: 2.175 mpg (US) / 6.6%

Attached Thumbnails
Click image for larger version

Name:	van-kammback-xls-cap.gif
Views:	2363
Size:	12.8 KB
ID:	2221  
__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
The Following User Says Thank You to MetroMPG For This Useful Post:
mannydantyla (02-01-2018)
Alt Today
Popular topics

Other popular topics in this forum...

   
Old 11-19-2008, 10:41 PM   #2 (permalink)
MechE
 
Join Date: Dec 2007
Location: Bay Area
Posts: 1,151

The Miata - '01 Mazda MX-5 Miata
Thanks: 0
Thanked 21 Times in 18 Posts
Quote:
Originally Posted by MetroMPG View Post
Cardboard Fabrication with Ducttape

This is a variation of Craig Vetter's CAD process: Cardboard Aided Design
I approve

Is the rear hatch still functional?
__________________
Cars have not created a new problem. They merely made more urgent the necessity to solve existing ones.
  Reply With Quote
Old 11-19-2008, 10:50 PM   #3 (permalink)
EcoModding Lurker
 
Join Date: Jul 2008
Location: Sweetwater, TN
Posts: 74

The Green Hornet - '96 Ford Escort Wagon LX
90 day: 39.26 mpg (US)

The Red Rocket - '96 Geo Metro Base
90 day: 53.07 mpg (US)
Thanks: 0
Thanked 2 Times in 2 Posts
I don't see how it could raise ALL the way, but looks like it might go most of the way.

Fun project!
__________________

  Reply With Quote
Old 11-19-2008, 11:02 PM   #4 (permalink)
Dartmouth 2010
 
SVOboy's Avatar
 
Join Date: Nov 2007
Location: Hanover, NH
Posts: 6,447

Vegan Powa! - '91 Honda CRX DX
Team Honda
90 day: 66.52 mpg (US)
Thanks: 92
Thanked 122 Times in 90 Posts
Send a message via AIM to SVOboy Send a message via MSN to SVOboy Send a message via Yahoo to SVOboy
Darin's amazing!
  Reply With Quote
Old 11-20-2008, 02:30 AM   #5 (permalink)
Moderate your Moderation.
 
Join Date: Nov 2008
Location: Troy, Pa.
Posts: 8,919

Pasta - '96 Volkswagen Passat TDi
90 day: 45.22 mpg (US)
Thanks: 1,369
Thanked 430 Times in 353 Posts
Quote:
Originally Posted by 93Cobra#2771 View Post
I don't see how it could raise ALL the way, but looks like it might go most of the way.

Fun project!
Unless, of course, the kammback were attached to the hatch, and sealed to the body with weatherstripping...

Legal implications for the taillights? Most states have a visibility provision in the vehicle code... outlining exactly how much (area) of your taillight must be visible from a given angle... mostly rearward, but I believe they might have something to say about your blocking light from the side/rear-angle view.

All in all, great work though.. and far less intelligence necessary to pull this off, making it a great mod in regard to effect vs. work/thought.

We all like the thoughtless mods... like we don't have enough stress in our lives to add physical permutations of fluid dynamics and airflow based on a given scale to our schedules... roffle.

All in all, a big .. can't wait for updates.
__________________
"¿ʞɐǝɹɟ ɐ ǝɹ,noʎ uǝɥʍ 'ʇı ʇ,usı 'ʎlǝuol s,ʇı"

  Reply With Quote
Old 11-20-2008, 06:01 AM   #6 (permalink)
X-Frenchy: very
 
groar's Avatar
 
Join Date: Jun 2008
Location: Toulouse, France
Posts: 595

scenic - '01 renault scenic
90 day: 43.09 mpg (US)

megane - '97 renault megane classic
Diesel
90 day: 72.53 mpg (US)

dennisius - '06 Toyota Prius
Team Toyota
90 day: 69.27 mpg (US)
Thanks: 9
Thanked 34 Times in 23 Posts
Incredible result
The minivan is so long compare to the Kammback that I would have bet the difference was going to be non-measurable.

It could be interesting to correlate the gain with the rear area reduction.

It could also be interesting to see efficiency difference when the lower part of the Kammback is cut-out at the light level.

(I will have to search again for an after-market cruise control available in France...)

Denis.
__________________
Save money & CO2 at home : http://ecorenovator.org/
Created and managed by the creators of http://ecomodder.com/
---
Earth and health are priceless, so are kilotank and AT-PZEV
Best Mégane tank: 1268.9mi @ 77.847 MPG(US)
2008/06-2011/10 saving:
  • 5725.5 kg CO2 (5342.6+382.9)
  • Diesel / Money: 42.17% = 2446.25€ = 3357.26$


---
megane : thread - kill switch.
  Reply With Quote
Old 11-20-2008, 08:34 AM   #7 (permalink)
EcoModding Apprentice
 
dichotomous's Avatar
 
Join Date: Nov 2008
Location: vermont
Posts: 142

CivySi - '03 honda civic SI
90 day: 31.99 mpg (US)
Thanks: 0
Thanked 1 Time in 1 Post
6% gas milage increase would be less 2mpg in that thing, thats hardly a deal to have to drive around with that on the back. I'm sorry but I dont feel 2mpg is enough of a savings to deal with that thing hanging off the back. you'd get better than 2mpg savings just driving ecostyle
__________________
  Reply With Quote
Old 11-20-2008, 09:58 AM   #8 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
At $3 gas, 6750 highway miles/year*, 23 mpg = $58 savings. Less as gas drops, more as it increases obviously.

Another note: the speed of testing was just 89 km/h / 55 mph. Actual savings of course increase with speed.

(* that's 45% of EPA's average annual distance of 15k miles total city+hwy)
__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Old 11-20-2008, 10:01 AM   #9 (permalink)
X-Frenchy: very
 
groar's Avatar
 
Join Date: Jun 2008
Location: Toulouse, France
Posts: 595

scenic - '01 renault scenic
90 day: 43.09 mpg (US)

megane - '97 renault megane classic
Diesel
90 day: 72.53 mpg (US)

dennisius - '06 Toyota Prius
Team Toyota
90 day: 69.27 mpg (US)
Thanks: 9
Thanked 34 Times in 23 Posts
Quote:
Originally Posted by dichotomous View Post
6% gas milage increase would be less 2mpg in that thing, thats hardly a deal to have to drive around with that on the back. I'm sorry but I dont feel 2mpg is enough of a savings to deal with that thing hanging off the back. you'd get better than 2mpg savings just driving ecostyle
Which ecomod is better than ecodriving ?

This 6% is granted whoever drives, ecodriver or not.
An ecodriver will have a 6% effort-less bonus, not negligible

15000 miles at 35mpg is 428 gallons
15000 miles at 33mpg is 455 gallons
Result : 455 - 428 = 27 gallons free and 250 kg CO2 not sent to the atmosphere (see my sig). My son (and I if I'm always alive) will thank these efforts in 50 years.

And this cardboard ecomod is only a test. Done in a more weather proof way, as metrompg and others know how to do it, it could be stealth. My white coroplast front grill block on my light grey car doesn't attire a lot of looks.

Denis.
__________________
Save money & CO2 at home : http://ecorenovator.org/
Created and managed by the creators of http://ecomodder.com/
---
Earth and health are priceless, so are kilotank and AT-PZEV
Best Mégane tank: 1268.9mi @ 77.847 MPG(US)
2008/06-2011/10 saving:
  • 5725.5 kg CO2 (5342.6+382.9)
  • Diesel / Money: 42.17% = 2446.25€ = 3357.26$


---
megane : thread - kill switch.
  Reply With Quote
Old 11-20-2008, 10:09 AM   #10 (permalink)
Batman Junior
 
MetroMPG's Avatar
 
Join Date: Nov 2007
Location: 1000 Islands, Ontario, Canada
Posts: 22,513

Blackfly - '98 Geo Metro
Team Metro
Last 3: 70.09 mpg (US)

MPGiata - '90 Mazda Miata
90 day: 52.71 mpg (US)

Even Fancier Metro - '14 Mitsubishi Mirage top spec
90 day: 70.75 mpg (US)

Appliance car - '14 Mitsubishi Mirage ES (base)
90 day: 60.16 mpg (US)
Thanks: 4,058
Thanked 6,957 Times in 3,602 Posts
Quote:
Originally Posted by trebuchet03 View Post
Is the rear hatch still functional?
It was effectively taped shut for the test, but I don't see why it couldn't be designed to open all the way if the lower sides were attached differently.

Quote:
Originally Posted by Christ View Post
Legal implications for the taillights?
Oh, yeah, that goes without saying.

This was just a quick 'n' dirty test. A permanent version (my brother has no interest in one) would need proper lighting - lights brought out to the end of the addition is the obvious solution.

__________________
Project MPGiata! Mods for getting 50+ MPG from a 1990 Miata
Honda mods: Ecomodding my $800 Honda Fit 5-speed beater
Mitsu mods: 70 MPG in my ecomodded, dirt cheap, 3-cylinder Mirage.
Ecodriving test: Manual vs. automatic transmission MPG showdown



EcoModder
has launched a forum for the efficient new Mitsubishi Mirage
www.MetroMPG.com - fuel efficiency info for Geo Metro owners
www.ForkenSwift.com - electric car conversion on a beer budget
  Reply With Quote
Reply  Post New Thread


Thread Tools




Powered by vBulletin® Version 3.8.11
Copyright ©2000 - 2024, vBulletin Solutions Inc.
Content Relevant URLs by vBSEO 3.5.2
All content copyright EcoModder.com